SELECTING BIOSCRUBBERS AT GAS CONTACT TIME OF 2 SECONDS FOR FOUL AIR TREATMENT AT A 340 MGD HEADWORKS
Abstract:The Orange County Sanitation District (OCSD) owns and operates two wastewater treatment plants that treat approximately 240 million gallons per day (mgd). Each plant has extensive foul air collection and treatment facilities. The plants treat over one million cubic feet per minutes (cfm). Odors must be controlled to levels that meet the emission requirements of the local South Coast Air Quality Management District (SCAQMD). OCSD's current discharge limit to meet SCAQMD regulations is 1 ppm of hydrogen sulfide (H2S). There is no current discharge limit for Volatile Organic Compounds (VOC) but a limit may be required in the future. In addition, because of the plants' proximity to residential areas, OCSD has voluntarily adopted a “good neighbor” policy that calls for no detectable odor at the plants' boundaries.
OCSD, in conjunction with the University of California at Riverside, has been conducting research for a number of years to optimize a biological process to effectively control odorous emissions at an economical cost. Biological treatment would reduce OCSD's use of chemicals for odor control, providing savings in operating costs and increasing safety for plant staff and the community.
The research has led to the development of a foam biotrickling filter system that can be operated at very low gas retention times (2 to 4 seconds compared to 14 to 40 seconds for typical biotrickling filters). OCSD has converted five full-scale chemical scrubbers to foam biotrickling filters by replacing the plastic packing with open-pore polyurethane foam blocks, and replacing the large recirculation pump with a smaller pump. The test results indicated that the performance capabilities of the biotrickling filter are promising for reduction of hydrogen sulfide, reduced sulfur compounds (RSC), odors, and volatile organic compounds. Long-term operation of the biotrickling filter demonstrated its capability to reduce hydrogen sulfide concentrations ranging from 35 ppmv to 50 ppmv by up to 98 percent.
OCSD is currently designing a new headworks facility to replace the existing headworks facility at its Plant No. 2. The new headworks facility will require odor treatment of foul air. To minimize odors at the plant's boundary, the headworks' odor control facility is being designed to reduce hydrogen sulfide concentrations to 0.15 ppm. The selected odor treatment technology for the project is two-stage treatment: foam biotrickling filters followed by single-stage chemical scrubbers. A majority of the odors will be removed biologically through the biotrickling filter; remaining odors will be removed by the chemical scrubber. Hence, chemical usage and operating cost will be reduced substantially.
The new headworks' odor control facility will be one of the largest biotrickling filter systems in operation in the United States, treating 188,300 cfm of foul air.
This paper discusses the design concepts for biotrickling filters, including two-stage treatment systems with control capabilities to allow for flexibility and redundancy of biological systems.
Document Type: Research Article
Publication date: 2004-01-01
More about this publication?
- Proceedings of the Water Environment Federation is an archive of papers published in the proceedings of the annual Water Environment Federation® Technical Exhibition and Conference (WEFTEC® ) and specialty conferences held since the year 2000. These proceedings are not peer reviewed. A subscription to the Proceedings of the Water Environment Federation includes access to most papers presented at the annual WEF Technical Exhibition and Conference (WEFTEC) and other conferences held since 2000. Subscription access begins 12 months after the event and is valid for 12 months from month of purchase. A subscription to the Proceedings of the Water Environment Federation is included in Water Environment Federation (WEF) membership.
WEF Members: Sign in (right panel) with your IngentaConnect user name and password to receive complimentary access. Access begins 12 months after the conference or event
- Subscribe to this Title
- Membership Information
- About WEF Proceedings
- WEFTEC Conference Information
- Learn about the many other WEF member benefits and join today
- Ingenta Connect is not responsible for the content or availability of external websites